自动上料一体搅拌车空气系统的维护！_常见问题_自动搅拌一体车_自动搅拌一体机

站内搜索

常见问题

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自动上料一体搅拌车空气系统的维护！

所属分类：常见问题发布时间：2021-09-23 来源：http://www.shanqijituan.cn/ 浏览量：0

如果在空的正常运行过程中气体回路系统发生故障，驱动力将线性下降，并且无法正常启动的现象将变得非常严重。

If the gas circuit system fails during the normal operation of empty, the driving force will decrease linearly, and the phenomenon that it cannot be started normally will become very serious.

1自动上料一体搅拌车空压机应水平安装，固定并通风。

1. The air compressor of the automatic feeding integrated mixer truck shall be installed horizontally, fixed and ventilated.

2.强大的抗风雨能力，不暴露在阳光下。

2. Strong weather resistance, not exposed to the sun.

3.调整气动自动开关的上限和下限。如果压力太低，气缸会减速，如果压力太高，气动系统的气密性会降低。

3. Adjust the upper and lower limits of the pneumatic automatic switch. If the pressure is too low, the cylinder will slow down. If the pressure is too high, the air tightness of the pneumatic system will be reduced.

4.使用自动上料一体搅拌车检查油位，并确保油位在量油尺的顶线和底线之间。当油位接近下限时，添加新油。

4. Use the automatic feeding integrated mixer to check the oil level and ensure that the oil level is between the top line and the bottom line of the dipstick. When the oil level approaches the lower limit, add new oil

5.确保皮带正确张紧。用手指推动皮带，使其松开约10毫米。更换传送带时，必须更换整个组以保持共同的张力。

5. Ensure that the belt is tensioned correctly. Push the belt with your fingers to loosen it by about 10mm. When replacing the conveyor belt, the entire group must be replaced to maintain a common tension.

6.由于气体系统中充满油，因此需要足够量的油和足够的正常运行。只有这样，才能同时使用独立式混合器的功率来延长气体系统的使用寿命。

6. Since the gas system is full of oil, sufficient oil and sufficient normal operation are required. Only in this way can the power of the independent mixer be used at the same time to prolong the service life of the gas system.

我们希望这对于自动上料一体搅拌车的气动系统的维护将是有用的。

We hope this will be useful for the maintenance of the pneumatic system of the automatic feeding integrated mixer.

上一页：搅拌一体机现场原材料的管理方式介绍下一页：夏季多功能搅拌车不能用过期或带伤的轮胎

热门产品 / HOT PRODUCT