欢迎光临山汽集团官方网站!

400-879-1999

点击拨打服务热线:400-879-1999
您现在所在的位置: 首页> 新闻资讯 > 行业动态 >
站内搜索
关于山汽

联系人:刘老师

电话:400-879-1999

公司:山东山汽工程机械(集团)有限公司

地址:山东省莱州市206国道与308省道交叉口东南50米

搅拌一体车出现哪些表现需注意?

所属分类: 行业动态 发布时间:2021-07-21 来源:http://www.shanqijituan.cn/ 浏览量:18

1.自动搅拌一体车工作状况突变,这个突变情况指的是搅拌车不正常的表现,比如:搅拌车发动机突然熄火,再启动困难,甚至不能启动,混凝土搅拌车在行驶过程中动力突然降低,行驶无力,;行驶中制动失灵或跑偏等等,出现这些情况就要引起重视。
1. The sudden change of the working condition of the automatic mixer truck refers to the abnormal performance of the mixer truck, such as: the engine of the mixer truck suddenly stops, it is difficult to restart, or even can't start, the power of the concrete mixer truck suddenly decreases in the process of driving, and the driving is weak,; In driving brake failure or deviation, etc., we should pay attention to these situations.
2.声音异常,就是自动搅拌一体车行驶中出现非正常的声响,当搅拌车在行驶过程中发出异常时,一般的老司机就能意识到车辆出现问题了,此时应该立即停车检查,严禁搅拌车“带病作业”。
2. Abnormal sound refers to the abnormal sound of the automatic mixing truck when it is running. When the mixer truck is running abnormally, ordinary old drivers will realize that there is something wrong with the truck. At this time, they should stop the truck immediately for inspection, and it is strictly forbidden for the mixer truck to "work with problems".
3.排气颜色不正常,自动搅拌一体车发动机在正常工作过程中,排出的尾气中的成分是二氧化碳和水蒸气,假如车辆的尾气中含有未完全燃烧的碳颗粒、碳氢化物、一氧化碳和大量的水蒸气,这时尾气的颜色可能变黑或变白,总之就是尾气颜色和平时不一样。这样的情况也要引起注意,及时查看问题根源。
3. The exhaust color is abnormal. During the normal operation of the engine of the automatic mixer truck, the components of the exhaust gas are carbon dioxide and water vapor. If the exhaust gas of the truck contains incomplete combustion of carbon particles, carbon hydride, carbon monoxide and a large amount of water vapor, the color of the exhaust gas may turn black or white. In short, the color of the exhaust gas is different from usual. We should pay attention to this situation and check the root cause of the problem in time.
4.过热高温:这些问题一般出现在搅拌车的发动机、变速器、驱动桥主减速器、差速器及制动器等总成上。比如,搅拌车发动机过热,多为冷却系统有问题,缺冷却液或泵不工作;变速器和驱动桥过热,多为缺润滑油所致;制动器过热,多为制动蹄片不回位引起的。以上现象有的可以通过仪表盘的报警灯反映出来,需要驾驶员平时多观察,也可以用手测试外表温度。
4. Overheat and high temperature: these problems generally appear in the mixer engine, transmission, drive axle, main reducer, differential and brake assembly. For example, the mixer engine overheating, mostly for the cooling system problems, lack of coolant or pump does not work; Transmission and drive axle overheat, mostly due to lack of lubricating oil; Brake overheating, mostly caused by brake shoes do not return. Some of the above phenomena can be reflected by the alarm light of the instrument panel, which requires the driver to observe more at ordinary times, or test the appearance temperature by hand.
5.渗漏,自动搅拌一体车渗漏是指水泥搅拌车的燃油、润滑油(齿轮油)、制动液(或压缩空气)以及动力转向系油液等的渗漏现象。这也是明显的故障症状,仔细观察就能发现。
5. Leakage. The leakage of automatic mixer truck refers to the leakage of fuel oil, lubricating oil (gear oil), brake fluid (or compressed air) and power steering system oil of cement mixer truck. This is also an obvious fault symptom, which can be found by careful observation.
6.燃油和润滑油消耗过量,燃油和润滑油消耗过量,表明自动搅拌一体车技术状况已恶化并已经产生了故障。
6. The excessive consumption of fuel and lubricating oil indicates that the technical condition of the automatic mixer truck has deteriorated and the fault has occurred.
热门产品 / HOT PRODUCT
6.5方系列搅拌车
推荐产品

6.5方系列搅拌车

3.5方B款自动搅拌一体车
推荐产品

3.5方B款自动搅拌一体车

3.5方平口搅拌车
推荐产品

3.5方平口搅拌车

4方同步旋转自动搅拌一体机
推荐产品

4方同步旋转自动搅拌一体机

5.5方平口搅拌车
推荐产品

5.5方平口搅拌车

1.8方自动搅拌一体机
推荐产品

1.8方自动搅拌一体机

2.6方平口搅拌车
推荐产品

2.6方平口搅拌车

3.5方多功能搅拌一体车
推荐产品

3.5方多功能搅拌一体车

5.5方自动搅拌一体车
推荐产品

5.5方自动搅拌一体车

6.5方系列搅拌车
推荐产品

6.5方系列搅拌车

3.5方C款自动搅拌一体机
推荐产品

3.5方C款自动搅拌一体机

3.5方B款自动搅拌一体机
推荐产品

3.5方B款自动搅拌一体机

2.6方自动搅拌一体机
推荐产品

2.6方自动搅拌一体机

4.0方自动搅拌一体机
推荐产品

4.0方自动搅拌一体机

3.5方A款系列搅拌车
推荐产品

3.5方A款系列搅拌车

2方后置驾驶室自动搅拌一体车
推荐产品

2方后置驾驶室自动搅拌一体车

1.8方多功能搅拌车
推荐产品

1.8方多功能搅拌车

1.2方自动搅拌一体车
推荐产品

1.2方自动搅拌一体车

3.5方D款自动搅拌一体机
推荐产品

3.5方D款自动搅拌一体机

3.5方C款搅拌一体车
推荐产品

3.5方C款搅拌一体车

首页 产品 电话 置顶