自上料搅拌车制动系统的重要性_ 行业动态_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自上料搅拌车制动系统的重要性

所属分类：行业动态发布时间：2022-04-01 来源：http://www.shanqijituan.cn/ 浏览量：0

自上料搅拌输送一体机是特殊的重型卡车，当混合燃料箱时，负载能力大并且道路条件变得复杂。由于惯性离心力的增加，对自上料搅拌输送一体机系统的制动系统提出了很高的要求。制动系统对于混合器系统非常重要，但是确定混合器要考虑的是轿厢的制动距离和制动器的热降解。如果卡车的制动系统出现问题，驾驶员和乘客也有危险。因此，踩踏或踩踏制动器时，请务必小心。

The self loading mixing conveyor is a special heavy truck. When mixing fuel tanks, the load capacity is large and the road conditions become complex. Due to the increase of inertial centrifugal force, high requirements are put forward for the braking system of self feeding mixing conveyor system. The braking system is very important for the mixer system, but the first consideration in determining the mixer is the braking distance of the car and the thermal degradation of the brake. If there is a problem with the braking system of the truck, the driver and passengers are also at risk. Therefore, be careful when applying or applying the brake.

1.制动时发出异常声音

1. Abnormal sound during braking

踩刹车时，刹车系统会引起强烈的金属摩擦。原因可能是刹车片上的异物或刹车盘生锈。

When the brake is applied, the brake system will cause strong metal friction. The reason may be foreign matters on the brake pad or rust on the brake disc.

2.制动踏板的行程变长

2. The travel of the brake pedal becomes longer

刹车变软时，您会看到笔直的白点。较长的制动冲程主要是由于空气进入制动系统，缺少制动油，可能的泄漏和制动衬块的严重磨损。

When the brakes soften, you will see straight white spots. The longer braking stroke is mainly due to air entering the braking system, lack of brake oil, possible leakage and serious wear of brake pads.

3.制动偏差

3. Braking deviation

制动器打滑不太常见，主要反映了在施加制动器时方向盘向一侧弯曲的事实。造成这种现象的原因可能是制动衬块偏心磨损和制动分泵出现问题。

Brake slip is less common and mainly reflects the fact that the steering wheel bends to one side when the brake is applied. This phenomenon may be caused by eccentric wear of brake pads and problems of brake wheel cylinder.

4.刹车越来越难

4. Braking is becoming more and more difficult

许多卡都有增加制动的问题。加强制动器的主要原因是真空助力器故障。刹车不辅助，经常使用刹车。

Many cards have the problem of increasing braking. The main reason for strengthening the brake is the failure of the vacuum booster. The brake is not assisted, and the brake is often used.

5.刹车回弹

5. Brake rebound

许多卡伙伴都遇到过这种情况，但是在制动时，会出现一种现象，其中上肢从制动踏板上弹起，主要是由于制动盘表面不平整。垫片和钢环变形。

Many card partners have encountered this situation, but when braking, there will be a phenomenon in which the upper limb bounces from the brake pedal, mainly due to the uneven surface of the brake disc. The gasket and steel ring are deformed.

以上就是为大家介绍的有关自动搅拌一体机的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.shanqijituan.cn/

The above is the detailed introduction of the automatic mixing machine. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.shanqijituan.cn/

上一页：混凝土自上料搅拌车的转速问题方法！下一页：多功能搅拌车做底盘润滑是需要注意的地方有哪些？

热门产品 / HOT PRODUCT