自动搅拌一体车是如何进行修复土壤残渣？_公司新闻_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自动搅拌一体车是如何进行修复土壤残渣？

所属分类：公司新闻发布时间：2020-10-30 来源：http://www.shanqijituan.cn/ 浏览量：0

自动搅拌一体车之类的混凝土机械在长期使用中不可避免地会出现某些故障。这时，我们需要对机械土壤渣进行一定的清理工作。因此，让我们仔细研究如何正确清理土壤。

In the long-term use of concrete machinery such as automatic mixer truck, some failures will inevitably occur. At this time, we need to clean up the mechanical soil residue. So let's look at how to clean up the soil properly.

1.准备应急驱动软管，关闭自动搅拌一体车，然后拆下液压马达上的高压油管接头。

1. Prepare the emergency drive hose, close the automatic mixer truck, and then remove the high-pressure oil pipe connector on the hydraulic motor.

2.关闭救援车辆，拆除液压马达的高压油管，将故障车辆上的相应连接器与应急驱动软管连接。

2. Close the rescue vehicle, remove the high-pressure oil pipe of the hydraulic motor, and connect the corresponding connector on the fault vehicle with the emergency drive hose.

3.发射救援车并将其手柄转到排放位置。故障车辆内部的混凝土被排出。

3. Launch the rescue vehicle and turn its handle to the discharge position. The concrete inside the faulty vehicle was discharged.

4.应急驱动器完成后，卸下驱动器软管并恢复两辆车的原始状态。

4. After the emergency drive is completed, remove the drive hose and restore the original state of the two vehicles.

5.在滚筒和滚道之间放一个木楔，以控制搅拌筒的旋转。请务必注意性。关闭发动机，并卸下液压马达的高压油管。搅拌筒可以自由旋转。

5. Place a wooden wedge between the drum and raceway to control the rotation of the mixing drum. Please pay attention to safety. Shut down the engine and remove the high pressure oil pipe from the hydraulic motor. The mixing drum can rotate freely.

自动搅拌一体车

6.控制搅拌桶的旋转，将维护孔转到下部，然后打开维护孔以清理圆筒内的混凝土。这时，我们必须注意。排出混凝土后，请恢复原来的混凝土搅拌车。

6. Control the rotation of the mixing drum, turn the maintenance hole to the lower part, and then open the maintenance hole to clean the concrete in the cylinder. At this time, we must pay attention to safety. After discharging the concrete, please restore the original concrete mixer.

通常情况下，在使用自动搅拌一体车时合理清洁土壤残留物可以确保所使用设备的良好运行性能。同时，在实际施工操作中，我们还需要更加注意设备的操作，也可以避免一些不必要的故障。

In general, the proper cleaning of soil residues can ensure the good operation performance of the equipment used. At the same time, in the actual construction operation, we also need to pay more attention to the operation of the equipment, also can avoid some unnecessary faults.

自动搅拌一体车关于修复土壤残渣问题的了解就是这样，希望对你有帮助。

This is what you know about repairing soil residue. I hope it will help you.

上一页：多功能搅拌车忽然不工作了是什么原因下一页：自动搅拌一体机的降温措施有哪些?

热门产品 / HOT PRODUCT