自动搅拌一体机是一个特种搅拌设备,要想上路务必要小心小心再小心,下面我们来看下都需要注意哪些事项;
The automatic mixing machine is a special mixing equipment. If you want to go on the road, you must be careful again and again. Let's take a look at what we need to pay attention to;
1、自动搅拌一体机运输混凝土过程中如车辆发生故障,出现罐体停转现象时,请按如下操作方法施救:(1)应检查是否为操纵机构故障,摆动操纵手柄观察油泵摆杆是否发生变化;(2)若操纵机构无异常,应尝试采用应急油管进行施救;若应急油管施救无效,则需要立即打开罐体检修孔将混凝土清理出来;若检修孔位置不合适,必须在前锥适当位置使用气割紧急开孔,然后以快的速度将罐内混凝土清理出来。
1. If the vehicle breaks down and the tank stops running during the transportation of concrete by the automatic mixer, please rescue according to the following operation methods: (1) first check whether it is the fault of the control mechanism, swing the control handle and observe whether the swing rod of the oil pump changes; (2) If the operating mechanism is normal, try to use emergency oil pipe for rescue; If the rescue of the emergency oil pipe is invalid, the tank physical repair hole shall be opened immediately to clean the concrete; If the position of the manhole is inappropriate, gas cutting must be used at the appropriate position of the front cone for emergency opening, and then the concrete in the tank shall be cleaned out as soon as possible.
2、自动搅拌一体机从混凝土入罐到排出,气温高时,2小时内尽量排出,阴雨天气温度低时,不宜超过3小时。
2. When the temperature is high, the concrete shall be discharged as far as possible within 2 hours. When the temperature is low in cloudy and rainy weather, it shall not exceed 3 hours.
3、自动搅拌一体机在排出混凝土之前,应使搅拌筒高速转动1分钟,再进行排料。
3. Before discharging concrete, the automatic mixer shall rotate the mixing drum at high speed for 1 minute before discharging.
4、自动搅拌一体机出料完毕,应立即用随车的软管放水,将进料口、出料斗及出料溜槽等部位冲洗干净,排去粘结在车身各处的混凝土,再向搅拌筒内注水150-200L的清水。在返回途中要让搅拌筒慢速转动,以清洗内壁,避免残余料渣附在筒壁和搅拌叶片上,在下一次装料前将这些水放掉。
4. After the discharge of the automatic mixing machine, drain the water with the hose on the vehicle immediately, wash the feed inlet, discharge hopper and discharge chute, drain the concrete bonded to the vehicle body, and then inject 150-200l of clean water into the mixing drum. On the way back, the mixing drum shall rotate slowly to clean the inner wall, avoid residual slag attached to the drum wall and mixing blades, and drain the water before the next loading.
5、自动搅拌一体机运送混凝土时,车速不得超过40km/h,以保证行车。
5. When the automatic mixer transports concrete, the speed shall not exceed 40km / h to ensure driving safety.
6、自动搅拌一体机工作完毕,应把搅拌筒内部和车身清洗干净。
6. After the automatic mixing machine is completed, the interior of the mixing drum and the vehicle body shall be cleaned.
7、自动搅拌一体机水箱的水量要经常保持装满,以备急用,冬季停机后,应将水箱、水泵、水管、搅拌筒内的水放净,并停放在朝阳、不积水的地方,以免冻坏机械。
7. The water volume of the water tank of the automatic mixing integrated machine shall be kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum shall be drained and parked in the sunny place without ponding to avoid freezing the machine.
8、检修自动搅拌一体机液压传动部分时,应使发动机和液压泵在没有压力的情况下进行。
8. When overhauling the hydraulic transmission part of the automatic mixing machine, the engine and hydraulic pump shall be operated without pressure.
9、检修自动搅拌一体机时,如需入罐操作,务必保证车辆熄火并拔出钥匙,防止误操作引起人员伤亡。
9. When repairing the automatic mixing machine, if it is necessary to enter the tank for operation, be sure to turn off the vehicle and pull out the key to prevent casualties caused by misoperation.
以上内容就是关于自动搅拌一体机http://www.shanqijituan.cn的介绍,希望这些内容对大家有所帮助。如果您还有什么疑问,或者想要了解更多资讯欢迎咨询我们官网。我们将竭诚为您服务。
The above content is about the automatic mixing machine http://www.shanqijituan.cn I hope these contents will be helpful to you. If you have any questions or want more information, please consult our official website. We will serve you wholeheartedly.