装载机型自给式搅拌机需要在冬季运行期间提供额外的保护措施,因为冬季温度相对较低,而长期零温对整个搅拌车来说实际上是非常不利的。这是一个条件。如果没有加强装载式自给式搅拌机的维护,搅拌机将冻结,因此预计冬季将达到以下五点。
The loading type self-contained mixer needs to provide additional protection during winter operation, because the temperature in winter is relatively low, and long-term zero temperature is actually very unfavorable to the whole mixer. This is a condition. If the maintenance of the loaded self-contained mixer is not strengthened, the mixer will freeze, so it is expected to reach the following five points in winter.
在冬季,装载机型自供应搅拌机在冬季“冻结”,装载机型自供应搅拌机在冬季“冻结”。
In winter, the self supply mixer of the loader is "frozen" in winter, and the self supply mixer of the loader is "frozen" in winter.
一,制动系统
1、 Braking system
请注意制动液的数量和质量,并根据需要添加或更换。根据需要清洁整个制动系统。
Please pay attention to the quantity and quality of brake fluid and add or replace it as needed. Clean the entire brake system as required.
二,轮胎
2、 Tires
冬季橡胶变得坚硬而且相对脆弱,但它不仅可以减少摩擦系统,而且在其他季节也相对渗漏。在冬季,始终清洁装载机型自动上料搅拌机的轮胎夹杂物,避免多次使用它来修理轮胎,并务必更换不同型号或企业的轮胎。
Rubber becomes hard and relatively fragile in winter, but it can not only reduce the friction system, but also relatively leak in other seasons. In winter, always clean the tire inclusions of the automatic loading mixer of the loader, avoid using it to repair the tire for many times, and be sure to replace tires of different models or brands.
三,预热
3、 Preheat
冬季温度低,润滑油粘度不流动,发动机启动后发动机保持在1100转/分钟左右,装载搅拌机预热后,加速器剧烈启动,发动机转速不高增加太多了。只要噪声指针温度计开始上升,选择的温度预热就不必等待发动机温度上升。
In winter, the temperature is low and the viscosity of lubricating oil does not flow. After the engine is started, the engine remains at about 1100 rpm. After the loading mixer is preheated, the accelerator starts violently, and the engine speed is not high, which increases too much. As long as the noise pointer thermometer starts to rise, the selected temperature preheating does not have to wait for the engine temperature to rise.
四,打蜡
4、 Waxing
随着冬季的流逝,磨砂装载机型自给式搅拌机的数量也会减少,因此早冬蜡是一种更好的维护涂料。此外,身体不容易接触水,冬天不容易在冰上凝结。
With the passage of winter, the number of self-contained mixers of frosted loader will also decrease, so early winter wax is a better maintenance coating. In addition, the body is not easy to contact water, and it is not easy to condense on the ice in winter.
5,刹车
5. Brake
虽然冬季驾驶刹车强调“早期”和“柔软”这两个词,但在冬季和其他季节,即使不在雪地或冰路上行驶,制动效果也不尽相同。如果与块式制动器结合使用,混合器制动灯应该更快。在冰面上,使用挡块保持发动机制动而不在路上制动。如有必要,您也可以使用手制动器,但必 须停止制动按钮放松,不要松开手制动器。请记住应用制动器以防止其冻结且制动器不起作用
Although the winter driving brake emphasizes the words "early" and "soft", the braking effect is different in winter and other seasons, even if you don't drive on snow or ice. If used in combination with a block brake, the mixer brake lamp should be faster. On ice, use the stop to keep the engine braking instead of braking on the road. If necessary, you can also use the handbrake, but you must stop the brake and release the button. Do not release the handbrake. Remember to apply the brake to prevent it from freezing and the brake does not work